a 0 a tA

L q A 2 s

and  Ba   are  equivalent  mass,  stiffness  and visco-damping

coefficient of accumulator, and Aa, Ba0, ktA are respectively area   of   cross   section   in   accumulator,   visco-damping

where

L L

B′ = BL + AL2/ktL.

coefficient of liquid part and gain of flow rate to pressure at inlet of accumulator, as well as pa0 and Va0 are the initial value of the pre-charge gas. The visco-damping coefficient Ba0  is small but the gain ktA  is large for the reason of low

By Eqs. (7)–(8), (12)–(16), reduction yields the structure

diagram of the model of the whole system as depicted in Fig. 7 and built in MATLAB. Here

A sG

viscosity  of  water  comparing  to  oil  hydraulics.  So   the

N11

= −    1 A    ,

1−G1GA

(17)

damping ratio

a = Ba/(2 ) « 0.1

and is under

damped seriously. It is necessary to reduce the gain ktA to depress the overshoot and oscillations.

The continuity of water flow and force balance equations

N12

= −  Cip  GA   ,

1−G1GA

(18)

CHINESE JOURNAL OF MECHANICAL ENGINEERING ·423·

N21 =

A3 sG′   ,

(19)

error for step response is obvious by reason of the resistance   of   throttle   valves,   injector,   pipes,   etc. The

N22

1+ G2GL

C   G′

= ip2       L    , 1+ G2G′

(20)

steady-state error can be reduced and the capacity of resisting disturbance can be enhanced, by closed-loop control of load pressure with integral  compensation and PID  control.  As  shown  in Fig.  7,  the  proportional relief

valve is a key component in the pressure control system.

N  = GL  ,

3

L

(21)

The poor control performance of the valve due to severe nonlinearity and low accuracy makes the linearization of the control loop very difficult. But the frequency   response

N4 =

1 ,

ms2  + Bs

pB

(22)

bandwidth of the water hydraulic proportional pressure relief valve, generally below 10 Hz, is much lower than the natural frequency of the WAIM  system. So in the   opinion

of  linear   controller  design  and   system  simulation,   the

N5  = ,

U

(23)

transfer function of the proportional relief valve can be simplified as a three-order loop like

G  = V1s + C  ,

(24)

1 ip1

e

  pB   = 

上一篇:RS485/以太网技术英文文献和中文翻译
下一篇:柔性制造系统调度的仿真英文文献和中文翻译

开关电源水冷却系统英文文献和中文翻译

微注塑成型工艺参数对成...

台湾绿色B建筑节水措施英文文献和中文翻译

轻水反应堆建模和复合燃...

海水淡化的优化设计英文文献和中文翻译

水下机器人AUV叶片冷锻钉...

船舶与海洋结构物水动力...

上海居民的社会参与研究

浅谈高校行政管理人员的...

酵母菌发酵生产天然香料...

提高教育质量,构建大學生...

从政策角度谈黑龙江對俄...

AES算法GPU协处理下分组加...

压疮高危人群的标准化中...

基于Joomla平台的计算机学院网站设计与开发

浅论职工思想政治工作茬...

STC89C52单片机NRF24L01的无线病房呼叫系统设计